Lg RAVENNA RDV3340 User Manual

Report No. 050-S-15c-5INSTALLATION AND OPERATION MANUALDirect-Vent Gas Fireplace InsertsRetain These Instructions For Future Reference WARNINGS• H

10NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.zero ClearanCe fireplaCe installationThis insert may be installed in a masonry or factory built/

11NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.4. Install a light layer of rockwool directly over the ports. - A light layer will give a mor

12NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Gas Line InstallationAfter leveling, position the insert in the fireplace - holding it about six

13NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Operating Instructionspre-lighting CheCklistBe sure to check these items before the initial ligh

14NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE. WARNINGS• Improper installation, adjustment, alteration, service or maintenance can c

15NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Flame Color & BehaviorYour Ravenna™ gas insert is designed for maximum heat-ing efficiency. T

16NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.operating optionsThe rocker switch on your Ravenna™ gas insert is used to turn the burner on and

17NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Maintenance & ServicingmaintenanCe CheCklistThe following should only be performed by a qua

18NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Fan Snap SwitchFan Speed ControlWhiteGround (Green)BlackBlowerBlack (Hot)White (Neutral)Power So

19SYMPTOM PROBABLE CAUSE CORRECTIVE ACTIONThin black coating (soot) forms on the viewing glass, logs, or fireboxImproper log or ember placementImproper

2Cautions & safetyFOR YOUR SAFETY do not install or operate your Ravenna™ gas insert without first reading & under-standing this man

20Replacement PartsRavenna™ 33/40 (RDV33/40)Part Number DescriptionH3132 Cassette Assembly NG 33,000 BTU (if LP, also requires H5433 Conversion

21NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Finish Panels/front SupportsCat. No. Description75252 "ZC Lower Finish Panel/Bay Face Suppo

22NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.MINIMUM CLEARANCES TO COMBUSTIBLES RDV40 RDV33E = Top Facing to Bottom of Insert 35.5”(90

23NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.CAUTION: YOUR COUNTRY GAS APPLIANCE MUST ALWAYS BE OPERATED WITH GLASS DOOR IN PLACE. STOP! Rea

Printed in U.S.A. © Lennox Hearth Products 2007P/N 775,218M REV. B 12/2007Lennox™ reserves the right to make changes at any time, without notice, i

3Table of ContentsCautions & safety ... 2orifiCe size / altitude

4Orifice Size/Altitude AdjustmentFor altitudes above 2,000 feet (In Canada 4,500 FT/1370 M),the orifice should be de-rated by 4% for every 1,000 feet to

5InspectionThe state or local gas inspector of the side wall horizontally vented gas fueled equipment shall not approve the installation unless, upon

6Pre-InstallationfeaturesInstallation Options Manufactured (Mobile) Home Natural Gas Or Propane (LP) Bedrooms Optional Wall-mounted Or Remote Th

7NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.insert dimensionsminimum fireplaCe opening requiredA = 29-3/4” (756mm) Front OpeningB = 19-1/

8NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Note: Hearth protection to be min. 3/8” (10mm) thick non-combustible or equivalent, with a k fact

9NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.vertiCal ventingThe vent pipes must be connected to the proper collars on the unit and the exhaus