Report No. 050-S-07b-5INSTALLATION AND OPERATION MANUALB-Vent Gas Fireplace InsertRetain These Instructions For Future Reference WARNINGS• Hot! Do
10NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.surround installationInstall per the following instructions (refer to Figure 13).The FireStar™ i
11NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Table 2lower front 2” filler panelThe FireStar™ insert comes with a 2” panel to fill the space be
12propane (lp) and natural gas suppliesYour Firestar™ gas insert is equipped from the factory for use with natural gas only as specified on the Safety
13Operating Instructionspre-lighting CheCklistBe sure to check these items before the initial lighting of the insert:- All packaging materials are
14NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.TO TURN OFF GAS TO APPLIANCE(Refer to controls shown in Figure 16)1. Turn off the "ON/OFF&q
15NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.paint CuringThis insert has been painted with Stovebright high tem-perature metallic sto
16millivolt Control systemThis insert operates on a millivolt control system. As such, no addition power supply is needed for the insert to operate.
17NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Maintenance & ServicingmaintenanCe CheCklistShould Only Be Performed by a Qualified Service T
18To remove the front door open the side doors, release the front door latches on either side and rotate the top of the glass door forward and down un
19NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.fuel Conversion & Cassette installationConverting your FireStar™ gas insert between natura
2Table of ContentsCautions & safety ... 3orifiCe size / altitude
20SYMPTOM PROBABLE CAUSE CORRECTIVE ACTIONThin black coating (soot) forms on the viewing glass, logs, or firebox1) Improper log or ember placement2) Im
21REPLACEMENT PARTS LISTPART # DESCRIPTIONH5952 #33 NG Main Burner OrificeH5953 #35 NG High Elevation Main Burner OrificeH5951 #50 LP High Elevatio
22Safety / Listing Label
23Lighting Label
24Your Fireplace Insert's Model Number ___________________________________Your Fireplace Insert’s Serial Number ________________________________
3NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.FOR YOUR SAFETY do not install or operate your Fire-star™ gas insert without first reading &
4NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Codes & ApprovalsCertifiCationGas appliances must be tested and certified by a nation-ally rec
5Pre-InstallationfeaturesInstallation Options Residential - Vented Vertical Only Manufactured (Mobile) Home Natural Gas Or Propane (LP) Bedrooms
6NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Figure 2minimum fireplaCe opening requiredA = 29-3/4” Front OpeningB = 19” HeightC = 19” R
7NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.(*Insert bottom is the metal lip below the lower gold trim bar).Note: Hearth protection to be min
8NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.Installationinsert ventingRefer to Figure 6 which shows a typical installation of this ap-pliance
9NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.zero ClearanCe fireplaCe installationThis insert may be installed in a masonry or factory built/z
Comments to this Manuals